2004 Chevrolet Colorado Electrical System Problems
- 76
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 76 stored complaint records:
- 0 indicate a crash
- 2 indicate injury
- 5 indicate fire
What owners report
- only work · 7 records
- blower motor · 7 records
- lock unlock · 7 records
- wiring harness · 6 records
- cruise control · 6 records
- same problem · 5 records
Mileage in stored records
| Band | Records |
|---|---|
| 60–100k mi | 24 |
| 1–30k mi | 13 |
| 100–150k mi | 12 |
| 30–60k mi | 11 |
| 150–400k mi | 5 |
Complaint records
Owner-submitted complaint content, presented as stored.
Electrical System
Tl* the contact owns a 2004 chevrolet colorado. The contact stated that the interior lighting, door chime, and radio did not turn off. The vehicle was taken to mayse automotive group (2032 s elliott ave, aurora, mo 65605) where it was determined that the wires running from the rear driver's side door had to be replaced; however, the parts for the repair were no longer being manufactured. The manufacturer was not…
ODI 11291347
Electrical System · Unknown Or Other
Vehicles bcm-body control module is defective or the system in its self is defective. Vehicles will not start or may shut off at random from time to time. Scan tools will not be able to recognize the problem as the bcm. So repairs made may make it seem like it fixed the problem but a couple hours/days/weeks later the problem will disguise it self as something else or even come back as the same problem. I myself was…
ODI 11024752
Electrical System · Engine
Idle control via electronic throttle body raises rpm very high when the accelerator pedal is not depressed, causing uncontrolled acceleration of vehicle during coasting or when brake pedal is applied. Turning the vehicle off with the key is the only action that has resulted in a cessation of extremely high idle. After restarting the vehicle, the symptom is gone and the vehicle operates normally. This behavior is…
ODI 11030226
Electrical System · Service Brakes
Problem # 1: had to replace the hvac resistor and its wiring harness. Resistor plug and the harness plug was burned and melted...fire hazard! This safety hazard could have burned up my vehicle. Problem #2: the abs warning light keeps coming on and when this happens (every day or so) the brakes do not work properly. This seems to happen when the vehicle is not parked on a level surface. The fault occurs once the…
ODI 10940409
Electrical System
I bought this vehicle in 2014 with only 86000 miles on it. I had to have brand new key cut and programmed when i purchased it. Starting in july of 2016 i started having issues with it not starting and cutting out. Now it won't start at all. It is the theft system not allowing it to start. I have read thousands of complaint about this issue over many different gm vehicles. Some nearly causing wrecks, stranding people…
ODI 11005139
Electrical System
I too have experienced problems with the hvac system of this truck. I have had to replace no less than 4 resistors and connectors due to melting and burned connections. I have not had to replace a single fuse. My hvac is once again inoperable and i have opened and inspected each connection point to locate the problem. I have found multiple connectors to be burned or melted. This problem has been flagged by the nhsta…
Fire reported
ODI 10816920
Air Bags · Electrical System
Airbag light is on. My truck has never been in an accident. Through research i have found that the wiring in the door breaks. *tr
ODI 10649683
Air Bags · Electrical System
A/c heater resistor and plastic connector for both resistor and blower motor arced and melted. Also air bag light is on. *tr
ODI 10632919
Electrical System
Turn ignition to off position and park indicator light and radio stays on. Have to jiggle key to get to go off. Come out several hours later and park indicator light and radio are back on./ also, heat and air control fan only works on high speed. I was told it was a resistor ,i replaced resistor and it still continues to do this. I can reach down and jiggle the resistor and it works on all speeds for a short while…
ODI 10627685
Control Module (Tcm, Pcm) · Electrical System · Engine
2004 chevrolet colorado. Consumer writes in regards to engine and ignition switch problems. *smd the consumer stated on april 12, 2014, the vehicle shut off while driving 30 mph. The brake pedal was hard to push and the dashboard read reduced power. After waiting three minutes, the consumer was able to re-start the vehicle. The vehicle stalled again, after driving two miles. According to the service invoice, the pcm…
ODI 10609385
Electrical System
I was making a left turn and i let the clutch out a little too fast which stalled the engine. I went to restart and engine just craned over and over would not start. That is where i almost got hit. Had to push trk thru intersection .i have had this problem with it not restarting for a few years now.i have to wait 10 minutes before restarting. It happens intermittently when i go to start it does not start. It just…
ODI 10576449
Electrical System
Tl* the contact owns a 2004 chevrolet colorado. The contact stated her vehicle would stall intermittently after it was turned on. The failure was diagnosed, both the dealer and manufacturer were aware of the failure. The vehicle was not repaired. The failure mileage was 117,000.
ODI 10577994
Electrical System · Fan/Motor
This incident occurred twice. It involves the heater blower motor resistor assembly. 8 years ago my daughter used put her back pack on the passenger floor where it repeatedly made impacted the connection to the blower motor relay assembly. This eventually caused the pin and socket on the orange wire to separate to the point where it arced and burnt. I found and repaired the socket when the heater would only work on…
ODI 10557570
Defroster/Defogger/Hvac System · Electrical System
The switch which controls the fan speed for the heat and a/c quit working. The fan only works when the it is set on high. *tr
ODI 10654526
Electrical System · Engine · Steering · Vehicle Speed Control
The ignition will not start at first. It takes multiple times in order to get the engine to turn over. Once the ignition does cause the engine to turn over, the vehicle will suddenly lose power while driving as the vehicle shuts itself off (as if the ignition has been turned off although it has not been). This has happened on multiple occasions in the course of normal driving activities, several times while crossing…
ODI 10638276
Air Bags · Electrical System
I put key into on position and airbag deployed and hit me in face. My face was red & swollen on right side where i was hit by bag. My truck not moving was parked my seatbelt was out side i was getting it on when bag deployed. Gm is giving me a hard time! I keep getting 1800 customer service numbers they gave me a pac # but they have not followed up with me or dealer. I bought the truck it had 101,000 on it has…
1 injury
ODI 10504052
Electrical System
Heater fan does not work. It is wintertime and i have two children ages 4 1/2 years and 9 months. Faulty wiring for the fan. *tr
ODI 10491874
Electrical System · Engine
Everyday now when i try to start the truck it turns over but will not start, wait 15 minutes then it will start. Today when i tried it the first time it turned over but would not start so when i turned it off at the key it stopped then tried to start again on its own for about 8 to 10 secs. The starter turned the engine over without touching the ignition switch it then stopped for about 3 or 4 secs then tried to…
ODI 10700963
Electrical System
The vehicle was parked and started up due to the snow/ice to melt the windshield. The fan would only work on the high setting which is "4". I replaced the resistor as it was burnt. It worked ok for a week and then burnt out again. If i jiggle the wires it will sometimes work on 1, 2 or 3 setting but not for very long. I have replaced 3-4 resistors and i'm tired of replacing them. Seems to me that this should be a…
ODI 10555958
Electrical System · Service Brakes
Abs fault light went on. Turned off engine, restart, light off. Goes on and off randomly. *tr
ODI 10477994
Electrical System
2004 chevrolet colorado. Consumer writes in regards to a defective ignition switch. *smd the consumer stated, he paid to have his ignition switch replaced, and is seeking reimbursement. He stated there were times, when the vehicle would not start, and it would take anywhere from 20-30 minutes. Over several years, he took the vehicle to the dealer, explaining the problems, with trying to start the vehicle. Each time…
ODI 10606312
Electrical System
Vehicle keeps stalling at idle or as you are slowing to stop at traffic lights, drive thru's... Acts as if it isn't charging properly. Have replaced battery, plugs, belt tensioner, drive belts. This is dangerous!!! I almost got hit again in morgantown! Brake lights, head & tail lights keep going out as well!!! My husband recently diagnosed with cancer. I am having to drive him back & forth to wvu hospital in the…
ODI 10501882
Electrical System
The vehicle fan control fails to function on settings 1, 2, or 3. Setting 4 functions properly. The connector plug at the fan housing and wiring harness shows signs of charring. *tr
ODI 10460396
Electrical System
Chevrolet has a known ignition system defect since march 2009. My 2004 chevrolet colorado intermittently does not start and then starts on the second try. Chevrolet's document: "#pip4575b: intermittent click no crank or brief crank no crank with dtcs - possible crank sensor - keywords bqmi - (mar 11, 2009)" explains the defect. I took my colorado in for service on 04-05-12 because it was not starting at all. They…
ODI 10454749
Electrical System
Dashboard lights not always coming on at night only odometer lights up.
ODI 10994271